设为首页收藏本站

中国电力科技论坛

 找回密码
 注册

QQ登录

只需一步,快速开始

搜索
热搜: 活动 交友 discuz
查看: 2583|回复: 7

FW型600MW超临界W火焰炉燃烧优化研究

[复制链接]
lssv 发表于 2012-1-21 14:16:22 | 显示全部楼层 |阅读模式
FW型600MW超临界W火焰炉燃烧优化研究
刘鹏远1,肖宏博2,赵兴华2,史俊3,金坪学2,廖永浩1
(1.华电电力科学研究院,杭州 310030;2.四川华电珙县发电有限公司,珙县 644502;
3.云南华电巡检司发电有限责任公司,弥勒 652309)
The Research of Combustion Adjustment of a FW Type Down-fired Boiler of Supercritical 600MW Unit
LIU Peng-yuan1 , XIAO Hong-bo 2 , ZHAO Xing-hua 2 ,SHI Jun3 ,JIN Ping-xue2 ,
,LIAO Yong-hao1
(1.China HuaDian Electric Power Research Institute, Hangzhou 310030, China;
2.Gongxian Power Generation Co. ,Ltd. ,Gongxian 644502, China;
3. Xunjiansi Power Generation Co. ,Ltd., Mile 652309, China )

Abstract: The NO.1 boiler of the Gong Xian power plant is the first domestic 600MW supercritical FW type down-fired boiler. The optimal design to the sub-critical down-fired boiler was introduced, and the optimizing adjustment for the milling and combustion system were carried out. The results showed that after the double-inlet and double-outlet mill had been equipped with dynamic separator, the fineness and uniformity of the pulverized coal have been improved impressively. Through the layout of burnout wind on the arch, the emission level of NOx has been decreased to almost 635 mg/Nm3. By the adjustment of excess air ratio and air distribution methods, carbon content in the fly ash can stabilize at about 4%, which is lower than the design value. Through the combustion optimization, the main parameters of the boiler can satisfy the design requirements, the load regulation performance is very good and the boiler can operate stably and safely.
Key words: Down-fired boiler; Fly ash in carbon content; The emission level of NOx
摘 要:珙县电厂1号锅炉为国内首台FW型600MW超临界W火焰炉。介绍了与同等级亚临界W炉的优化改进,并进行了制粉及燃烧系统进行优化调整,结果表明:双进双出磨煤机配备动态分离器后,煤粉细度和均匀性得到有效提高;通过在拱上布置燃尽风,NOx排放含量降至约635 mg/Nm3;通过对运行氧量及配风方式调整,试验后期飞灰可燃物稳定在4%左右,低于设计值。通过燃烧优化后,锅炉各主要参数均能达到设计要求,负荷调节性能良好,可安全稳定运行。
关键词:W火焰锅炉;飞灰可燃物;NOx排放
1设备概况
游客,如果您要查看本帖隐藏内容请回复
zaomenyuan 发表于 2013-2-11 23:49:24 | 显示全部楼层
恢复一下,支持
tw5404 发表于 2013-3-20 15:07:30 | 显示全部楼层
恢复一下,支持
焊接论坛 发表于 2013-11-29 00:21:24 | 显示全部楼层
很想了解,
zhaodapeng 发表于 2014-2-16 19:17:32 | 显示全部楼层
认真学习一下
北漂 发表于 2015-2-16 11:26:45 | 显示全部楼层
学习一下。
光明 发表于 2016-1-15 15:22:48 | 显示全部楼层
您好!谢谢您!
zzg19731999 发表于 2016-4-8 15:47:01 | 显示全部楼层
学习看看啊
您需要登录后才可以回帖 登录 | 注册

本版积分规则

池作和-具有超强防结渣性能纳米陶瓷涂层

Archiver|手机版|小黑屋|中国电力科技网 ( 鲁ICP备09062776号  

GMT+8, 2024-3-29 04:15

Powered by Discuz! X3.2

© 2001-2013 Comsenz Inc.

快速回复 返回顶部 返回列表